How to remove and install a power steering pump while ensuring proper procedures and precautions in non-turbo engine on BMW 335i?

Remove the intake air filter housing and drain the power steering fluid reservoir using a clean syringe, ensuring not to reuse the fluid. Raise the front of the car and remove the splash shield from under the engine. Take off the accessory belt from the power steering pump, marking the direction of rotation if the belt is to be reused. While working under the vehicle, release the hose clamp and detach the low-pressure fluid hose from the pump, being prepared to catch any dripping fluid. Plug the openings in the pump and hose ends to prevent contamination. Remove the fastener for the A/C refrigerant line clamp and the fasteners for the power steering pump bracket. Detach the high-pressure fluid hose from the pump by removing the banjo bolt, again being prepared for dripping fluid, and plug the openings to prevent contamination. Remove the fasteners and take the power steering pump out from below. When installing the pump, replace aluminum fasteners with new ones, tighten the pump fasteners finger tight, and follow the specified tightening sequence: tighten side bracket fasteners to 2 Nm (18 in-lb), then tighten front bracket fasteners to 2 Nm (18 in-lb) before tightening the front bracket fasteners to the final specification. Release the side bracket fasteners and ensure the bracket is flush with the engine block, then tighten the side bracket fasteners to the final specification. The remainder of the installation is the reverse of removal, ensuring to replace sealing rings on the high-pressure fluid hose, fill and bleed the hydraulic system, and check for leaks.

How to drain and replace the power steering pump and fluid in the M54 six cylinder engine on BMW X3?

Empty the power steering fluid taking as a caution, not to refill the same fluid back to the power steering system. Junction the car to a lifting point and lower the front of the car, then self deploy of the left front wheel, then reduce the splash shield located under the engine. Take the accessory belt off the power steering pump; if the belt is to be reused, place a mark on it showing the direction of its rotation. Having the vehicle raised, the hoses connected to the pump have to be disconnected, which is why wear protective gloves and napkins to clean up any dripping fluids. Detach the clamp on the suction hose and disconnected its end that was connected to the pump and remove the pressure fitting and pressure line. Screw tight the plug on the holes at the ends of the pump and the hose to curb contamination. At the front side of the Pump, unbolt the power steering pully and then remove it. Take off the idler pulley of the alternator, then unbolt the pump, paying attention to special spacers and shims if there are any and having removed the pump from the engine compartment. Removal is the exact opposite of installation and involves removing the pressure fitting seal and then the hose clamp of the fluid lines. Last but not the least, refill and also bleed the power steering system.

Genuine BMW Power Steering Pump

Power Steering Pump Unit

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Series

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

176 Power Steering Pumps found

View related parts
BMW Tandem Pump
Part Number: 32416788909
$1751.38 MSRP: $2439.39
You Save: $688.01 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
Fits the following BMW Models:
- 550i GT | 2010-2012 | F07
- 550i GT xDrive | 2010-2017 | F07
- 550i xDrive | 2011-2016 | Sedan(F10)
- 650i xDrive | 2012-2018 | Convertible(F12), Coupe(F13)
- 650i xDrive Gran Coupe | 2013-2019 | F06
- 750i | 2009-2012 | Base(F01), Sedan(F01)
- 750i xDrive | 2010-2015 | Sedan(F01)
- 750Li | 2009-2012 | Base(F02), Sedan(F02)
- 750Li xDrive | 2010-2015 | Sedan(F02)
- Alpina B6 xDrive Gran Coupe | 2015-2019 | F06
View More
View related parts
BMW Tandem Pump
Part Number: 32416783962
$1556.39 MSRP: $2167.79
You Save: $611.40 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
- Replaces: 32-41-6-772-128, 32-41-6-781-006
Fits the following BMW Models:
- X5 | 2007-2010 | 3.0si(E70), xDrive30i(E70)
View related parts
BMW Exchange Power Steering Pump
Part Number: 32412229679
$729.95 MSRP: $784.54
You Save: $54.59 (7%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
Fits the following BMW Models:
- M3 | 2001-2006 | Convertible(E46), Coupe(E46)
- Z3 M | 2001-2002 | Coupe(E36), Roadster(E36)
View related parts
BMW Exchange Power Steering Pump
Part Number: 32416757914
$655.66 MSRP: $908.84
You Save: $253.18 (28%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
Fits the following BMW Models:
- X5 | 2001-2006 | 3.0i(E53)
View related parts
BMW Power Steering Pump
Part Number: 32413428010
$740.58 MSRP: $1031.50
You Save: $290.92 (29%)
Ships in 1-3 Business Days
ADD TO CART
Fits the following BMW Models:
- X3 | 2007-2010 | 3.0si(E83)
View related parts
BMW Power Steering Pump
Part Number: 32416756582
$639.57 MSRP: $690.39
You Save: $50.82 (8%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaces: 32-41-1-093-577
Fits the following BMW Models:
- 320i | 2001-2005 | Sedan(E46)
- 323i | 1998-1999 | Convertible(E36)
- 323is | 1998-1999 | Coupe(E36)
- 325Ci | 2001-2006 | Convertible(E46), Coupe M54 Engine(E46), Coupe(E46)
- 325i | 2001-2005 | Sedan M54 Engine(E46), Sedan(E46), Wagon M54 Engine(E46), Wagon(E46)
- 328i | 1996-1999 | Convertible(E36), Sedan(E36)
- 328is | 1996-1999 | Coupe(E36)
- 330Ci | 2001-2006 | Convertible(E46), Coupe(E46)
- 330i | 2001-2005 | Sedan(E46)
View More
View related parts
BMW Power Steering Pump
Part Number: 32416769887
$673.28 MSRP: $937.77
You Save: $264.49 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaces: 32-41-4-038-714, 32-41-4-039-954, 32-41-4-035-682, 32-41-4-036-733, 32-41-4-042-171
Fits the following BMW Models:
- 128i | 2008-2013 | Convertible N51 Engine(E88), Convertible N52 Engine(E88), Coupe N51 Engine(E82), Coupe N52 Engine(E82)
- 323i | 2006-2011 | Sedan(E90)
- 325i | 2006 | Sedan(E90)
- 325xi | 2006 | Sedan(E90), Wagon(E91)
- 328i | 2007-2013 | Convertible N51 Engine(E93), Convertible N52 Engine(E93), Coupe N51 Engine(E92), Coupe N52 Engine(E92), Sedan N51 Engine(E90), Sedan N52 Engine(E90), Wagon(E91)
- 328i xDrive | 2009-2013 | Coupe N51 Engine(E92), Coupe N52 Engine(E92), Sedan N51 Engine(E90), Sedan N52 Engine(E90), Wagon(E91)
- 328xi | 2007-2008 | Coupe N51 Engine(E92), Coupe N52 Engine(E92), Sedan N51 Engine(E90), Sedan N52 Engine(E90), Wagon(E91)
- 330i | 2006 | Sedan(E90)
- 330xi | 2006 | Sedan(E90)
View More
View related parts
BMW Power Steering Pump
Part Number: 32412283002
$807.93 MSRP: $1125.31
You Save: $317.38 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaces: 32-41-2-283-003
Fits the following BMW Models:
- M3 | 2008-2013 | Convertible(E93), Coupe(E92), Sedan(E90)
View related parts
BMW Hydraulic Pump
Part Number: 32416856680
$1126.77 MSRP: $1569.40
You Save: $442.63 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
Fits the following BMW Models:
- X5 | 2014-2018 | xDrive35i(F15)
- X6 | 2015-2019 | xDrive35i(F16)
View related parts
BMW Tandem Pump
Part Number: 32416760071
$1506.16 MSRP: $2097.84
You Save: $591.68 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
Fits the following BMW Models:
- 760i | 2004-2006 | Sedan(E65)
- 760Li | 2003-2008 | Sedan(E66)
View related parts
BMW Tandem Pump
Part Number: 32416783964
$1556.39 MSRP: $2167.79
You Save: $611.40 (29%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
- Replaces: 32-41-6-772-123, 32-41-6-781-019
Fits the following BMW Models:
- X5 | 2007-2010 | 4.8i(E70), xDrive48i(E70)
View related parts
BMW Vane Pump
Part Number: 32416760034
$623.33 MSRP: $672.85
You Save: $49.52 (8%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
Fits the following BMW Models:
- 320i | 2001-2005 | Sedan(E46)
- 325Ci | 2001-2006 | Convertible(E46), Coupe M54 Engine(E46), Coupe M56 Engine(E46), Coupe(E46)
- 325i | 2001-2005 | Sedan M54 Engine(E46), Sedan M56 Engine(E46), Sedan(E46), Wagon M54 Engine(E46), Wagon M56 Engine(E46), Wagon(E46)
- 330Ci | 2001-2006 | Convertible(E46), Coupe(E46)
- 330i | 2001-2005 | Sedan(E46)
View More
View related parts
BMW Power Steering Pump
Part Number: 32416777321
$1288.43 MSRP: $1324.56
You Save: $36.13 (3%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaces: 32-41-4-035-679, 32-41-4-038-768
Fits the following BMW Models:
- 525i | 2006-2007 | Sedan(E60)
- 525xi | 2006-2007 | Sedan(E60)
- 528i | 2008-2009 | Sedan(E60)
- 528i xDrive | 2009-2010 | Sedan(E60)
- 528xi | 2008 | Sedan(E60)
- 530i | 2006-2007 | Sedan(E60)
- 530xi | 2006-2007 | Sedan(E60), Wagon(E61)
View More
View related parts
BMW Vane Pump
Part Number: 32416760036
$623.33 MSRP: $672.85
You Save: $49.52 (8%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Power Steering Pump
Fits the following BMW Models:
- 320i | 2001-2005 | Sedan(E46)
- 323Ci | 2000 | Convertible(E46), Coupe(E46)
- 323i | 1999-2000 | Sedan(E46), Wagon(E46)
- 325Ci | 2001-2006 | Convertible(E46), Coupe M54 Engine(E46), Coupe(E46)
- 325i | 2001-2005 | Sedan M54 Engine(E46), Sedan(E46), Wagon M54 Engine(E46), Wagon(E46)
- 328Ci | 2000 | Coupe(E46)
- 328i | 1999-2000 | Sedan(E46)
- 330Ci | 2001-2006 | Convertible(E46), Coupe(E46)
- 330i | 2001-2005 | Sedan(E46)
View More
View related parts
BMW Power Steering Pump
Part Number: 32412283041
$807.93 MSRP: $1125.31
You Save: $317.38 (29%)
Ships in 1-3 Business Days
ADD TO CART
Fits the following BMW Models:
- M3 | 2008-2010 | Convertible(E93), Coupe(E92), Sedan(E90)
View related parts
BMW Power Steering Pump
Part Number: 32413450590
$889.88 MSRP: $1239.45
You Save: $349.57 (29%)
ADD TO CART
Fits the following BMW Models:
- X3 | 2007-2010 | 3.0si(E83)
View related parts
BMW Power Steering Pump
Part Number: 32416781003
$1155.37 MSRP: $1609.24
You Save: $453.87 (29%)
Ships in 1-3 Business Days
ADD TO CART
Fits the following BMW Models:
- X5 | 2007-2010 | 3.0si(E70), xDrive30i(E70)
View related parts
BMW Power Steering Pump
Part Number: 32416794350
$1300.12 MSRP: $1810.85
You Save: $510.73 (29%)
Ships in 1-3 Business Days
ADD TO CART
Fits the following BMW Models:
- 535i GT | 2010-2013 | F07
- 535i GT xDrive | 2011-2017 | F07
- 535i xDrive | 2011-2016 | Sedan(F10)
- 640i xDrive | 2014-2018 | Convertible(F12), Coupe(F13)
- 640i xDrive Gran Coupe | 2014-2019 | F06
- 740i | 2011-2012 | Sedan(F01)
- 740Li | 2011-2012 | Sedan(F02)
- 740Li xDrive | 2013-2015 | Sedan(F02)
View More
View related parts
BMW Exchange Power Steering Pump
Part Number: 32411137952
$343.31 MSRP: $437.22
You Save: $93.91 (22%)
Product Specifications
- Other Name: Power Steering Pump
- Replaces: 32-41-1-138-129, 32-41-1-141-246, 32-41-1-140-841
Fits the following BMW Models:
- 320i | 1993-1995 | Sedan(E36)
- 325i | 1992-1995 | Convertible(E36), Sedan(E36)
- 325is | 1991-1995 | Coupe(E36)
View More
View related parts
BMW Tandem Pump
Part Number: 32416783965
$1515.27 MSRP: $2110.52
You Save: $595.25 (29%)
Product Specifications
- Other Name: Power Steering Pump
- Replaces: 32-41-6-781-022, 32-41-6-772-122
Fits the following BMW Models:
- X5 | 2007-2010 | 4.8i(E70), xDrive48i(E70)

| Page 1 of 9 |Next >

1-20 of 176 Results

BMW Power Steering Pump

A BMW power steering pump directs steering fluid to a car's steering mechanism, which allows the driver to steer with minimal effort. Like any other car part though, the power steering pump can wear out through regular wear and tear after a long period of usage. Environment factors like rust and corrosion can also impede functionality of the pump, as well as a driving a car low on power steering fluid.

BMW Power Steering Pump Parts Questions & Experts Answers

Power Steering Pump
32416779244
Q: How to remove and install a power steering pump while ensuring proper procedures and precautions in non-turbo engine on BMW 335i?
A:
Remove the intake air filter housing and drain the power steering fluid reservoir using a clean syringe, ensuring not to reuse the fluid. Raise the front of the car and remove the splash shield from under the engine. Take off the accessory belt from the power steering pump, marking the direction of rotation if the belt is to be reused. While working under the vehicle, release the hose clamp and detach the low-pressure fluid hose from the pump, being prepared to catch any dripping fluid. Plug the openings in the pump and hose ends to prevent contamination. Remove the fastener for the A/C refrigerant line clamp and the fasteners for the power steering pump bracket. Detach the high-pressure fluid hose from the pump by removing the banjo bolt, again being prepared for dripping fluid, and plug the openings to prevent contamination. Remove the fasteners and take the power steering pump out from below. When installing the pump, replace aluminum fasteners with new ones, tighten the pump fasteners finger tight, and follow the specified tightening sequence: tighten side bracket fasteners to 2 Nm (18 in-lb), then tighten front bracket fasteners to 2 Nm (18 in-lb) before tightening the front bracket fasteners to the final specification. Release the side bracket fasteners and ensure the bracket is flush with the engine block, then tighten the side bracket fasteners to the final specification. The remainder of the installation is the reverse of removal, ensuring to replace sealing rings on the high-pressure fluid hose, fill and bleed the hydraulic system, and check for leaks.
Power Steering Pump
32413450590
Q: How to drain and replace the power steering pump and fluid in the M54 six cylinder engine on BMW X3?
A:
Empty the power steering fluid taking as a caution, not to refill the same fluid back to the power steering system. Junction the car to a lifting point and lower the front of the car, then self deploy of the left front wheel, then reduce the splash shield located under the engine. Take the accessory belt off the power steering pump; if the belt is to be reused, place a mark on it showing the direction of its rotation. Having the vehicle raised, the hoses connected to the pump have to be disconnected, which is why wear protective gloves and napkins to clean up any dripping fluids. Detach the clamp on the suction hose and disconnected its end that was connected to the pump and remove the pressure fitting and pressure line. Screw tight the plug on the holes at the ends of the pump and the hose to curb contamination. At the front side of the Pump, unbolt the power steering pully and then remove it. Take off the idler pulley of the alternator, then unbolt the pump, paying attention to special spacers and shims if there are any and having removed the pump from the engine compartment. Removal is the exact opposite of installation and involves removing the pressure fitting seal and then the hose clamp of the fluid lines. Last but not the least, refill and also bleed the power steering system.

Related BMW Parts

Browse by Model